Mercedes S-class W202

1993-2000 of release

Repair and car operation


Mercedes W202
+ 1.2. The general data
- 2. Maintenance service
   + 2.1.1. The engine
   2.2. In addition through each 60 000 km of run
   2.3. Every 2 year
   2.4. Every 3-4 year
   - 2.5. Works on maintenance service
      + 2.5.1. The engine and system of release of the fulfilled gases
      - 2.5.2. A box predach/the main transfer
         2.5.2.1. The visual control of tightness
         2.5.2.2. Check of level of oil in differential
         2.5.2.3. Check of disks of hinges карданного a shaft
         2.5.2.4. Check of rubber cuffs of semiaxes
      + 2.5.3. The forward bridge / a steering
      + 2.5.4. Tyre Brakes /
      + 2.5.5. The Body / internal illumination
   + 2.6. Care of the car
   2.7. Start of the engine from the auxiliary accumulator
   2.8. Car towage
   2.9. Car lifting
   2.10. The tools applied to maintenance service
+ 3. Engines
+ 4. Greasing system
+ 5. Cooling system
+ 6. Heating, ventilation
+ 7. Ignition system
+ 8. Fuel system
+ 9. Transmission
+ 10. A running gear
+ 11. A steering
+ 12. Brake system
+ 13. A body
+ 14. An electric equipment
+ 14.2. Electroschemes












2.5.2.2. Check of level of oil in differential
THE GENERAL DATA

Oil level in differential is necessary for checking only in the event that in this zone at visual check thinnesses have been found out. It is not necessary to change oil in differential of the back bridge.

PERFORMANCE ORDER
1. Spend a short-term trial trip that oil in differential has reached working temperature.
2. Преподнимите the car in a horizontal plane.
3. Unscrew a carving stopper маслоналивного apertures (the right arrow) by means of a wrench on 14 for bolts with шестигранным deepening, for example, HAZET 2760. A carving stopper of a drain aperture (the left arrow).
4. If the oil small amount acts, it corresponds to normal level. Otherwise check up a finger, whether level of oil reaches an aperture bottom edge. If is not present, add oil by means of a manual butterdish.
The prevention

In case of rather big leak of oil define its reasons and eliminate malfunction.

The oil specification: трансмиссионное oil for гипоидных transfers of mark SAE 90. Thus apply only the oil resolved by firm Mercedes (it is specified on a manual butterdish).

For cars with automatically blocked differential (the index is on a cover of the back bridge) apply only special трансмиссионное oil SAE 90 to blocked differentials.

Transmissionnoe oil is viscous, therefore do not pour it at once too much. Accordingly wait a pause and substitute a vessel for catching of the poured oil.
5. Screw with the moment 50 Н.м. A carving stopper маслоналивного apertures.