Mercedes S-class W202

1993-2000 of release

Repair and car operation

Mercedes W202
+ 1.2. The general data
+ 2. Maintenance service
+ 3. Engines
+ 4. Greasing system
+ 5. Cooling system
+ 6. Heating, ventilation
+ 7. Ignition system
+ 8. Fuel system
+ 9. Transmission
+ 10. A running gear
+ 11. A steering
+ 12. Brake system
+ 13. A body
- 14. An electric equipment
   14.1.2. Measuring devices
   14.1.3. Technics of measurements
   14.1.4. Electric equipment checks
   14.1.5. A sound signal
   14.1.6. Replacements of safety locks
   + 14.1.7. The storage battery
   + 14.1.8. The generator
   + 14.1.9. A starter
   14.1.10. The traction relay
   - 14.1.11. Illumination system Lamps of near, distant and antifog light A lamp in a forward lantern of the index of turn A lamp in a back lantern A lamp in a lantern of illumination of licence plate A plafond in salon A lantern of the index of turn
      - A headlight Adjustment of headlights A back lantern
   14.1.12. Devices
   14.1.13. The instrument panel
   14.1.14. Lamps накаливания on the panel of devices
   14.1.15. Light switch
   14.1.16. A radio receiver
   + 14.1.17. The aerial
   14.1.18. Dynamics
   + 14.1.19. Rubber brushes of screen wipers
   14.1.20. Jets стеклоомывателя
   14.1.21. Washing atomizers of headlights
   14.1.22. A screen wiper and its engine
   14.1.23. Protect the car
   14.1.24. Anticreeping "immunodeficiency"
   14.1.25. Why headlights grow dull
   14.1.26. "Галогенки"
+ 14.2. Electroschemes A headlight

14. Штеккер for a lantern of the index of turn
30. Штеккер for illumination
32. A hose to the device for clearing рассеивателя headlights (фароочиститель or фароомыватель)
33. The pneumatic pipeline
М6/2х1, М6/3х1. Штеккер the screen wiper engine to the left / to the right

22. A nut 23. A washer
24. The lever of a neck of a screen wiper
25. A protective casing
26–29. Screws
34. A bolt
Е1, Е2. Headlights, at the left / on the right
М6/2, М6/3. Engines of screen wipers of headlights at the left/on the right
М6/2х1, М6/3х1. Штеккеры engines of screen wipers at the left / on the right


1. Remove a lantern of the index of turn.
2. Remove from a headlight electric wires and the pneumatic pipeline for adjustment on height.
3. If is available, remove the lever of a brush of a screen wiper (24) headlights. For this purpose cast away upwards a protective casing, unscrew a nut (22) and remove it together with a washer (23).
4. Depending on equipment, unscrew a cross-beam or lateral protective casings in a zone of fastening of headlights.
5. Unscrew two screws (26) and unhook a protective casing (25) under a headlight.
6. Unscrew screws (27–29) and cautiously extend a headlight forward. Close the shock-absorber a rag not to scratch it.
7. If is available, remove a hose to the device for clearing рассеивателя headlights.
8. If it is necessary to take out рассеиватель an optical element of a headlight, remove rubber consolidation. Take from spring clips above and below two supporting earrings (38). Remove рассеиватель an optical element (9) together with consolidation (21).


1. If it is removed, insert рассеиватель an optical element of a headlight into the case and simultaneously press it until supporting earrings above and below will not be fixed with click.
2. In advance check up consolidation on absence of porosity, if necessary replace it.
3. The further installation is carried out in sequence, return dismantling.
4. After assemblage end adjust headlights in a specialised repair truck.